Harley-Davidson Motor Company Recall List

List of the Harley-Davidson Motor Company recalls announced through NHTSA

Some of the listed recalls may apply to multiple models. All affected models can be found in the details of each recall below.

110 results found

Recent Recalls

22. 9. 2005

Harley-Davidson Motor Company – THROTTLE CABLE

ON CERTAIN MOTORCYCLES, THE THROTTLE CABLES COME INTO CONTACT WITH THE TUNNEL PORTION OF THE FUEL TANK.

21. 6. 2005

Harley-Davidson Motor Company – ANTI-LOCK BRAKE SYSTEM

ON CERTAIN POLICE AND ESCORT MOTORCYCLES, THE ANTI-LOCK BRAKE SYSTEM (ABS) LINES MAY HAVE BEEN REVERSED DURING INSTALLATION PROCEDURES.

14. 4. 2005

Harley-Davidson Motor Company – INCORRECT CERTIFICATION LABEL

CERTAIN SOFTAIL MOTORCYCLES FAIL TO COMPLY WITH THE REQUIREMENTS OF PART 567, 'CERTIFICATION.' THE VIN/CERTIFICATION LABEL CONTAINS INCORRECT TIRE SIZE AND INFLATION PRESSURES FOR THE FRONT WHEEL. THE LABEL STATES…

23. 12. 2004

Harley-Davidson Motor Company – HARLEY-DAVIDSON/FUEL VALVE

CERTAIN MOTORCYCLES MAY HAVE BEEN PRODUCED WITH DEFECTIVE FUEL SHUT-OFF VALVES. THE FUNCTIONALITY OF THE 'ON' POSITION AND THE 'RESERVE' POSITION OF THE VALVE MAY HAVE BEEN REVERSED.

21. 12. 2004

Harley-Davidson Motor Company – HARLEY-DAVIDSON/REPLACEMENT FUEL VALVES

CERTAIN FUEL SHUT-OFF VALVES USED AS REPLACEMENT EQUIPMENT, P/NOS 61338-02, 62169-02A, 61338-94D, AND 62169-95C FOR USE ON CERTAIN 2005 CARBURETED SPORTSTERS, DYNA, SOFTAIL, AND TOURING MODEL MOTORCYCLES. THESE VALVES MAY…

6. 12. 2004

Harley-Davidson Motor Company – HARLEY-DAVIDSON/ABS BRAKES WIRING HARNESS

CERTAIN POLICE MOTORCYCLES WERE BUILT WITH A DEFECTIVE WIRING HARNESS. THE ANTILOCK BRAKE SYSTEM (ABS ) IS WIRED THROUGH THE SAME FUSE CIRCUIT AS THE ABS MALFUNCTION WARNING LIGHT.

26. 11. 2004

Harley-Davidson Motor Company – HARLEY-DAVIDSON/ACCESSORY VOLTAGE REGULATOR

CERTAIN HARLEY-DAVIDSON AFTERMARKET VOLTAGE REGULATOR COVERS, P/N 74593-04 THAT CAN BE INSTALLED ON 2004 AND 2005 FXD, FXDX, FXDI, FXDXI DYNA GLIDE MOTORCYCLES, OR 2005 FXDC AND FXDCI DYNA GLIDE…

30. 9. 2004

Harley-Davidson Motor Company – HARLEY-DAVIDSON/FUEL CANISTERS

ON CERTAIN MOTORCYCLES, A CONDITION OCCURS THAT COULD ALLOW PRESSURE TO BUILD UP IN THE FUEL TANK. ON FUEL INJECTED VEHICLES, THIS CONDITION COULD CAUSE FUEL TO SPRAY OUT UNEXPECTEDLY…

7. 5. 2004

Harley-Davidson Motor Company – HARLEY-DAVIDSON/TAIL LIGHT BULB

ON CERTAIN DYNA, XL, AND TOURING MOTORCYCLES, THE TAIL LIGHT BULB CAN FALL OUT OF THE SOCKET.

18. 3. 2004

Harley-Davidson Motor Company – HARLEY-DAVIDSON/CIRCUIT BREAKER

ON CERTAIN TOURING AND POLICE MODEL MOTORCYCLES, THE 40 AMP MAIN CIRCUIT BREAKER CAN "OPEN" FOR REASONS OTHER THAN WHICH IT WAS DESIGNED, CAUSING AN UNEXPECTED INTERRUPTION OF ALL ELECTRICAL…