FREIGHTLINER LLC Recall List

List of the FREIGHTLINER LLC recalls announced through NHTSA

Some of the listed recalls may apply to multiple models. All affected models can be found in the details of each recall below.

216 results found

Recent Recalls

17. 3. 2000

FREIGHTLINER LLC – FREIGHTLINER/12 VOLT POWER OUTLET

VEHICLE DESCRIPTION: HEAVY DUTY TRUCKS EQUIPPED WITH CERTAIN 12 VOLT POWER OUTLETS. AN UNPLUGGED HOLE IN THE FLOORBOARD CAN ALLOW ROAD SALTS AND MOISTURE INTO AN AREA WHERE A 12…

15. 2. 2000

FREIGHTLINER LLC – FREIGHTLINER/PART 567/CERTIFICATION

VEHICLE DESCRIPTION: MOTOR HOME CHASSIS. THE TIRE PRESSURE ON THE CERTIFICATION LABELS ARE INCORRECT FOR THE DESIGNATED GROSS AXLE WEIGHT RATING. THIS DOES NOT COMPLY WITH REQUIREMENTS OF PART 567,…

27. 1. 2000

FREIGHTLINER LLC – FREIGHTLINER/FONTAINE/FIFTH WHEEL MOUNTING PLATE

VEHICLE DESCRIPTION: HEAVY DUTY CLASS 8 TRUCKS EQUIPPED WITH FONTAINE FIFTH WHEEL ASSEMBLIES. THE FIFTH WHEEL MOUNTING PLATES CAN CRACK.

18. 1. 2000

FREIGHTLINER LLC – FREIGHTLINER/ABS VALVE

VEHICLE DESCRIPTION: HEAVY DUTY TRUCKS. A HEAT SHIELD BETWEEN AN ABS (ANTI LOCK BRAKE SYSTEM) MODULATING VALVE AND A MUFFLER WAS OMITTED.

18. 1. 2000

FREIGHTLINER LLC – FREIGHTLINER/BRAKE MOUNTING BRACKET

VEHICLE DESCRIPTION: RV CHASSIS. IF THE FRONT WHEELS ARE TURNED WHEN THE AIR SUSPENSION IS EXHAUSTED, THE BRAKE CHAMBER MOUNTING BRACKET COULD BE DAMAGED DUE TO AN INTERFERENCE.

3. 1. 2000

FREIGHTLINER LLC – FREIGHTLINER/HALDEX/FMVSS 121

VEHICLE DESCRIPTION: HEAVY DUTY TRUCKS EQUIPPED WITH HALDEX MANIFOLD DASH VALVES (MDV) USED IN TRACTOR AND TRAILER PARKING BRAKES. THESE VALVES DO NOT MEET THE REQUIREMENTS OF FMVSS NO. 121,…

29. 12. 1999

FREIGHTLINER LLC – FREIGHTLINER/FRONT AXLE ASSEMBLY

VEHICLE DESCRIPTION: HEAVY DUTY TRUCKS. THE TIE ROD ENDS CAN FRACTURE DUE TO LOW STRESS, HIGH CYCLE, REVERSED BENDING FATIGUE RESULTING FROM A SYSTEM RESONANCE.

14. 12. 1999

FREIGHTLINER LLC – FREIGHTLINER/BRAKE PEDAL

VEHICLE DESCRIPTION: HEAVY DUTY TRUCKS. THE BRAKE PEDAL PIVOT PIN RETAINERS MAY NOT HAVE BEEN PROPERLY INSTALLED.

26. 10. 1999

FREIGHTLINER LLC – FREIGHTLINER/STEERING AXLE HUB

VEHICLE DESCRIPTION: HEAVY DUTY TRUCKS. THE OUTBOARD BEARING ON THE STEERING AXLE HUBS CAN FAIL DUE TO WATER INTRUSION THROUGH A HUBCAP VENT.

20. 9. 1999

FREIGHTLINER LLC – FREIGHTLINER STEP VAN THROTTLE CABLE BINDING

VEHICLE DESCRIPTION: HEAVY DUTY TRUCKS. THE THROTTLE CABLE CAN BIND DUE TO MISALIGNMENT WITH THE FUEL PUMP ASSEMBLY.